广西顶博发电机组制造

13667715899

添加微信好友了解产品w13667715899

当前位置:首页 > 技术支持

又到暴雨潮湿季节了,广西顶博发电机组制造进水该怎么办?

2021-07-31
来源: 原创
10631
当梅雨季节或大风季来监时,有有可能会备受洪涝气象灾害、强降水等自然是气象灾害的作用,因静音汽车发动因带风能发电站工作冷水空气能热泵通信机房基本是在地下水室还是1楼简易被水淹,假若带风能发电站工作冷水空气能热泵贮存安全防护网疏忽还是另外现状水有有可能会从烟管走进汽车发动因缸体。当静音汽车发动因带风能发电站工作冷水空气能热泵泡水时,可以在机器运行请立刻断电,并利用有必要的的方案,断开连接外电压及蓄电板接驳线,的同时诊断多个区域的泡水现状。


When the rainy season or typhoon season comes, it may be affected by natural disasters such as flood and rainstorm. Because the diesel generator set room is generally in the basement or the first floor, it is easy to be flooded. If the generator set is poorly kept and protected or for other reasons, water may enter the engine cylinder from the smoke pipe. When water enters the diesel generator set, if it is running, please shut down immediately, take necessary measures, disconnect the external power supply and battery connection line, and check the water inflow at all parts at the same time.


广西顶博发电机组制造机房


检查广西顶博发电机组制造进水常见问题

1、检测排气阀门线路(排烟口管极低处或排气消音器器)的排水道建筑构件需不需要滴水排尽。Check the exhaust pipe to see if there is water discharged from the drainage component.


2、定期检查热空气机油滤清器硬壳能否有的积水情况,燃油滤清器能否被水浸渍。Check whether there is water in the air filter housing and whether the filter element is immersed in water.


3、捡查生产发变频电动机壳子侧面是否是有存水。Check whether there is water accumulated at the bottom of the generator casing.


4、检查报告水冷器、换气扇、齿轮联轴器等旋转气缸结构件有没不通。Check radiator, fan, coupling for blockage.


5、对外部是充分油、燃料或水的渗漏。Whether there is leakage of organic oil, fuel or water from the outside.


6、卸下来拐臂室盖,查看有无有水进。排查风能发直流电机电机绕线电绝缘/造成的污染现状。Remove the rocker chamber cover and observe whether there is water ingress. Check the insulation and ontamination of the generator windings.


7、检则保持层面和输入输出集成运放的绝缘层。检则保持控制面板接口、各电子仪表、告警设施、初始化触点开关。Check the insulation between the control circuit and the output circuit. Check the control panel module, each instrument, alarm device and start switch.


需注意:肯定是不能让水注入打着机的助燃室!Note: Never let water enter the combustion chamber of the engine!


存水处里技术重油带发高压电设备进行进水后的治理辦法:Treatment  after water enter the generator:


当理解重油带发电量飞机设备起驱动力的熔化室如果没有浸水,绝缘层不符合耍求时,可起动重油带发电量飞机设备。在起动时要主要有以下相关问题:When confirm there is no water in the combustion chamber  and the insulation meets the requirements,can start the generator. Pay attention to the following issues when starting:


1、在开始一往无前行全部查检,包涵废气气油箱积水情况。高压电器系统性逐渐上电,考察是不是也有异常处理。Do all inspections before starting, including draining water in the fuel tank. The electrical system is gradually powered on, and observe whether there is any abnormality.


2、接连通电打火机的时期不允许突破十秒钟。若打火机不许火灾,则全面检查汽油线路及电气开关控制回路,两三分钟左右后从新通电。Start the engine continuously shall not exceed 30 seconds. If the engine cannot catch fire, check the fuel line and electrical circuit, and start again after one or two minutes.


3、检杳汽车发心理说话声什么情况下有发现异常,什么情况下有刺鼻味道。检杳电子商务义表的表明、体现屏表明屏什么情况下断屏又或者表明不清。


Check whether the engine sound is abnormal and whether there is a peculiar smell. Check whether the display of the electrical instrument and the LCD screen are broken or unclear.


4、融洽分析起驱力润滑油各种压力和水热度,如若油压机或热度不相按照技艺规定,应关闭系统起驱力。宕机后,检修一些起驱力润滑油正等轴测图。Closely observe the oil pressure and water temperature. If the oil pressure or temperature does not meet the technical specifications, the engine should be shut down. After stopping, check the oil level.


当分辨汽车发心理可能会进水量、火力发三相电动机隔绝不一致合需要时,切记不要私自维修部,应合作英语火力发三相电动空气能工厂的非常专业系统的人员的促进。When it is judged that water may enter the engine and the insulation of the generator does not meet the requirements, do not repair it without authorization, and seek the help of professional technicians from the generator manufacturer.


强降水/发潮的环境,柴油发动机火力发三相电冷库机组选用目光注意点Key points for unit operation in rainstorm / humid environment


1、放到条件需要1. Placement environment requirements(1)室外放上使用的的空气能热泵机组,需准备好防水防水设备,配制防水防水棚、靜音箱等;


Rainproof measures shall be taken for units placed outdoors, and rainproof sheds, static speakers, etc. shall be equipped;


(2)机柜硬壳须有安全可靠的保护区跨接线,对所需有比较适中点简单跨接线的风能发同步电机,则可以由专科的人员开展比较适中跨接线;The shell of the unit must be reliably grounded. For generators requiring direct neutral grounding, the neutral grounding must be carried out by professionals;


(3)打雷单发地段选用机气,请设置防雷安全装置。If machines are used in lightning prone areas, please configure lightning protection devices.


(4)请不必将制冷机组储放于地貌较低,房基不牢(土壤水平面)更易结水的去处;Please do not place the unit in a place with low terrain, weak foundation (soil ground) and easy to accumulate water;


(5)放到在地埋式室操作的广州POS机,需做到地埋式室排水系统、防湿上班。For machines placed in the basement, drainage and moisture-proof work in the basement shall be done well.
推建篇文章
柴油发电机厂家 柴油发电机厂家 柴油发电机厂家 柴油发电机厂家 柴油发电机厂家